2001 Volvo V70 Throttle Body Cleaning

You can clean the throttle using intake cleaner and a wire brush. First 40 mi but know its acting up again.

How Rare Is It 2001 V70 T5m

I then let that sit for 30 minutes or so and came back with an old toothbrush and scrubbed it.

2001 volvo v70 throttle body cleaning. Remove the cover plate by prying up on the edges with a small screwdriver. Dont worry about the Special Volvo Cleaner it doesnt work very well anyway. Flushing And Checking The Throttle Unit Flush the throttle unit using cleaner H on both sides of the throttle.

Use carb cleaner on a rag not soaking wet but enough to clean the TB. Where VIDA fault tracing indicates cleaning of crankcase breather is necessary First Measure the crankcase pressure in accordance with TNN 25-149-B Checking Crankcase Ventilation System. The approach I took was to just soak a paper towel in carb cleaner and stuffed it into each end of the throttle body.

First off the non turbo throttle body doesnt fail nearly as much as the turbo cars dont know why they just dont and cleaning them does help with jerky idle. Disconnect the intake from the throttle body. Take off whatever vacuum lines needed to get the bolts off remember where they go.

Slacken off the hose clamp for the air pipe on the throttle body ETM and remove the pipe from the ETM 6. Here are some photos from before the cleaning. You will now see the intake the throttle body and the throttle wheel.

Any remaining deposits can cause a new build up of deposits. Install the Throttle Unit. Most of the debris can be removed by a shop rag however you may have to deal with some harder carbon buildup with a brass bristle wire brush.

Clean again if necessary. There are 3 screws that hold in the cable section. Open the throttle blades with the throttle control.

It is glued down with silicone. Clean with throttle body cleaner and wipe with a lint free cloth Also a good time to inspectclean around the oil filter housing. I recently cleaned replaced one and cleaned the Pcv system with new oil tank and hoses And its still wont run right.

How To Clean Volvo Throttle Body. If required based on the diagnosis clean the crank case ventilation PCV in accordance with TNN 25-149-C Cleaning the Crankcase Ventilation. Where the pipe joins the engine will be the throttle body and it can become choked up with oil deposits and carbon If you remove the intake pipework by undoing the hose clips youll be able to wiggle the hose out of the way and use some rag and brake cleaner to wipe out the inside of the throttle body to clean.

If the deposits are not too thick and have not cooked or. The class-action suit concerns a July 2001 Volvo notice to dealers agreeing to pay for one ETM cleaning per customer. Pop the link to the throttle body with a screwdriver make sure not to twist it or bend up the link.

How to clean throttle body on volvo c70 2001. Same procedure for replacing. Under the cover plate you will see a computer module that is also siliconed in place.

Spray throttle body cleaner on a clean shop rag and clean the inside of the throttle body. Hello If you locate the air filter box in the engine bay big square box on the RHS there should be a large diameter pipe of about 25 running back from the box to the engine. Remove the throttle body from the engine.

Start by cleaning the inner housing and wipe the rag along the entire surface. Remove the 4 screws for the ETM 8. It did at first.

Check that there are no deposits remaining on the air duct or on the throttle disc. Remove the throttle body and unclip the wiring Depress 2 x tabs on the connector and pull off Ensure you dont lose the green silicon rubber gasket 5. This is a simple job so dont get scared and you can do this yourseld with some cleaner a rag and a small brush just remove everything around the throttle body and you can go to your local auto parts store and buy a cleaning kit for about 5.

Step 1 Volvo throttle body servicing. Tighten with 10 Nm - the intake manifold between the air cleaner ACL and the throttle body TB and the connected hoses - the intake pipe between the front cover plate and the air cleaner ACL - the cable to the battery negative terminal. To install proceed in the reverse order.

Ordering software Order applicable software. Is there a recalibrationreset for a throttle body on a 2001 Volvo XC70 turbo. The ETM will now be loose carefully remove if from behinf the inlet manifold.

Wipe clean the edge of the throttle disc. You will see a black plastic cover with a single torx screw holding it down. Undo the three as well what the arrows point too the wire harness.

Cleaning an ETM unit on a 2001 Volvo V70 24T. Follow the ETM cable route disconnect it and let it loose. Use a brass brush as its a softer metal and will not score the throttle.

In many cases however owners have paid for the work because their warranties had expired or they did not know the throttle was covered. Install - new throttle body with new gasket.

Volvo Etm Clean Replace Turbo Models V70 S60 S80 Throttle Body Volvo Volvo 850 Volvo V70